* Note: Some companies have introduced a very low loading and gradient loading system, as well as a low-volume hopper profile to reduce the amount of sheet consumed, the production of a rail system with very poor spectacle characteristics and low maintenance without preserving , The lack of use of the gearbox at the top and cost for the horizontal space of the upper part and the installation of the engine in the bottom of the rail system, loading solids and .... In this case, some of the solids will not enter into the mixer when it falls into the mixer, and it will not be fully loaded, and will slow down due to the poor profile of the rails. The loaded angle should be between and degrees in the rail system. For example, in order to load at a height of meters, the mixer should have an angle of meters and should be used with a heavy -stroke
Presentation of the production line and equipment for artificial stone, for the production of artificial flooring artificial stone engineering Similar to Coreen and Quartz cement base and polymer base, for the implementation of artificial stone engineering in the interior flooring, office centers, hospitals, yard floor and sidewalk, flooring Parking lots and ... with the ability to run on the project site
Secondly, because of the permanent moisture in these areas of the building, if used with natural stones, minerals in the stone texture can be deposited on the natural stone surface and deposited on the surface of the rock in a state of dandruff. Due to the use of minerals in synthetic rocks, Plast Cement is also a natural stone, unless used to produce a water absorption material using a special water absorption material, which will affect the cost of the finished product.
Specifications for Alvator Artificial Stone Production Line: Plast Cement square meters: Automatic transport of aggregates (and adhesive compounds) with a capacity of kg / min and an entrance and exit valve with an elevation of cm, with an electromotor of . / horsepower, With special custom envelopes and double edges and chains of Taiwan and ... With Hopper weighing After the pre-mixer and weight mixer for weighing materials, a * -cylinder jack, with a hinged lever and ocular steering wheel, and a protective guard against wind and dampness Corresponding pneumatic
In tiles and ceramics, due to the glazing on them, water absorption is very low, which is why they will be very slippery when they reach the smallest moisture level. In cement stone products, plast cement due to water absorption of about %, despite the moisture content of the product, is sufficiently frictional to prevent slippage. Also, on the flooring of Cement Plast, despite the gloss and the appearance of a perfectly polished surface, it is designed on the surface of a highly elaborate peeling product, which increases the friction between the surface of the product and the abrasive and prevents slipping. There is a standard on the floors and standard of national Iran, called resistance to slip (resilience to frustration) that all plast cement products are in compliance with this standard.